|
Enduro Engine - 2 stroke Cylinder, Piston, Tranny, Bearings, Clutch, Pipes & Silencers, etc. |
|
Thread Tools | Display Modes |
#1
|
||||
|
||||
Weird one - oil leak
Here's a weird one. 2002 300 EC.
In 2007, I did a top end and went behind the clutch cover, replacing starter parts. Oil tight since then. Rode the bike 2 weeks ago. Washed it, put it on the stand. Went to put new front struts in the mighty Volvo wagon last saturday, and noticed that the bike had a puddle of oil beneath it. Quite a bit as the oil level was down. Hmmmm. Degreased last night, had dinner, and after dinner, looked for leaks. Wet (oil) between case and right side cover. Changed oil (to fill trans), and let sit overnight to see if i will have a drop from the leak point, solidly identifying the source of the leak. Luckily, i am a pessimist, and have clutch cover, side cover, and water pump gaskets at home. Anyone hear of a gasket going bad? (Hoping against case porosity). My XR-250 did the same thing....the gasket was installed wrong at the factory (kink), it ran for almost 2 years before it began to leak, but when it leaked, it leaked badly. my plan is to take it apart tonight, hopefully having a drop as a clue. it wold be reassuring to find that the gasket went bad, or that i put botched the gasket, and after 5 years, it's sprung a leak. blitz |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Weird noise? | K Vee Gee | Other GasGas Bikes/Quads | 1 | 04-09-2012 11:25 AM |
Leak leak leak... | AnthGG | Enduro Engine - 2 stroke | 4 | 12-15-2011 08:10 PM |
Coolant leak | speeddemon | Enduro Engine 4 stroke (including EFI & Exhaust) | 2 | 02-04-2011 09:28 AM |
Voltage leak | nitroman | Enduro Engine 4 stroke (including EFI & Exhaust) | 8 | 04-13-2008 06:05 AM |
Gas cap leak? | colinmc400 | Enduro Chassis & Body | 6 | 05-21-2007 07:09 AM |