|
Enduro Engine - 2 stroke Cylinder, Piston, Tranny, Bearings, Clutch, Pipes & Silencers, etc. |
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
EC125 clutch problems
Has anyone here had a problem with an EC125 hydraulic clutch? I have a friend who has one that just won't keep pressure in the slave cylinder. He has had it into a reputable shop three or four times and the problem seems to be the rubber seal in the slave. The seal leaks and the clutch fluid enters into the engine oil. It holds pressure for a couple hours of riding and then leaks again.
I'm thinking that the piston or casing of the slave might be damaged and it causes the seal to get damaged. Is their any special trick to installing the piston into the slave? Maybe it is getting damaged upon installation? Sent from my iPhone using Tapatalk |
#2
|
||||
|
||||
Are you sure they use the correct type of seal and fluid? If using a seal that is incompatible with the fluid, strange things may happen. Dot4 or mineral oil...
Sent fra min GT-I9295 via Tapatalk
__________________
Anders "So you know, that you're over the hill when your mind makes a promise that your body can't fill" (Little Feat: Old Folks Boogie) 2015 EC200 Racing: TE bars, Rekluse Core Exp 3.0, 38mm Lectron & Ohlins S3 steering damper 2006 EC200: 2011 plastics, Rekluse Z-Start, revalved KYB forks & Scotts steering damper 1998 Bimota Supermono 1986 Duc Mille S2 1975 Guzzi sidecar hack 1961 Morini Corsaro 125 etc |
#3
|
||||
|
||||
Yes make sure you are using the correct fluid first.
2nd - check the slave bore condition. I had a Husqvarna hyd clutch where the slave cylinder plating wore through and needed to be replaced. |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
how to fix MOST clutch problems + cr250r clutch conversion. | stainlesscycle | Enduro Engine - 2 stroke | 70 | 10-26-2020 04:06 AM |
01 ec125 clutch problem | michalt95 | Enduro Engine - 2 stroke | 19 | 04-16-2014 08:45 PM |
EC125 2008 clutch fiber plates | Leon_gasgas | Enduro Engine - 2 stroke | 6 | 12-07-2011 03:59 AM |
Clutch problems | gaser | Enduro Engine - 2 stroke | 5 | 11-15-2010 07:51 AM |