Rieju & GasGas Legacy Riders Club Forum  

Go Back   Rieju & GasGas Legacy Riders Club Forum > GasGas Enduro Technical Forums > Enduro Engine - 2 stroke

Enduro Engine - 2 stroke Cylinder, Piston, Tranny, Bearings, Clutch, Pipes & Silencers, etc.


 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
  #1  
Old 03-09-2009, 01:58 PM
PBWR450 PBWR450 is offline
Member
 
Join Date: Nov 2008
Location: Missouri
Posts: 31
Default Unidentified engine/gearbox noise

I finally had a chance this weekend to air out the 01 EC250 I bought last fall. Recent maintenance includes a cylinder replate to A specs with a Vertex piston, bottom con rod side to side clearance was within spec and there appeared to be no up/down play. Clutch has recently started to rattle some at idle, possibly dampers because it goes away when clutch lever pulled in.

Anyway, while at a poker run this weekend part of the course was a good clear uphill section. While climbing this section in 4th gear about 1/2 throttle I began to hear a squeling almost grinding type noise that appeared to be coming from the right side. It immediately went away after dropping the revs. I ran the section again in 3rd gear at the same RPM range and did not hear any noise. I then tried it again in 4th and the noise came back at about the same RPM range as before. Anyone have a clue what may be causing this?
Reply With Quote
 



Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


Similar Threads
Thread Thread Starter Forum Replies Last Post
EC300 engine noise fittal Enduro Engine - 2 stroke 6 11-03-2010 09:42 AM
Engine noise roostafish General Discussions & Announcements 11 11-24-2009 12:01 PM
ec 400 gearbox issue Paul Somerville Enduro Engine 4 stroke (including EFI & Exhaust) 3 09-05-2009 10:17 AM
Milky gearbox oil juzzasmith Enduro Engine - 2 stroke 10 03-12-2007 05:40 PM
2002 ec 250 Engine noise thingymijig Enduro Engine - 2 stroke 5 02-22-2007 05:08 AM




All times are GMT -5. The time now is 06:51 AM.


Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.
Copyright 2009 - GasGasRider.org