|
General Discussions & Announcements General Announcements, General Questions, e.g. What bike do I buy?, etc. |
|
Thread Tools | Display Modes |
#1
|
||||
|
||||
Anyone else see the 2010/11 gas cap gasket shrink?
mine fell out and wouldn't go back on. I ordered a new cap from Hall's and the old gasket is maybe 10% smaller than the new one. I am assuming that the ethanol in our fuel is shrinking them up? More EPA fail?
__________________
Rob Granger / Katy, TX EC300 Breaking more things by 8:00AM than most people break all day. |
#2
|
|||
|
|||
Mine did the same thing, and after a few months your new cap and gasket will have the same problem. GASGAS has a problem with their rubber supplier. To fix the problem I just made my own gasket out of and old tire tube. It took less than 10 min and fixed the problem.
Last edited by MJC; 07-22-2011 at 02:09 PM. |
#3
|
||||
|
||||
Run out to your Ford diesel truck and take the gasket out of the radiator cap on the degas bottle.
Fits like a champ. Last edited by gasgasman; 07-22-2011 at 02:07 PM. Reason: added cap on the |
#4
|
||||
|
||||
Quote:
jk... sorry .. could not resist...
__________________
broken down over 60 slow rider.. |
#5
|
||||
|
||||
'bout the only thing useful off the 6.0L diesel.
|
#6
|
||||
|
||||
Heaps of similar threads on this forum. my 07 did it after about 6 months. We don't have any kind of blended fuel here in NZ. I cut a new gasket out of some epoxy/cork gasket material and it's been fine. Kinda annoying that GG have done nothing about this - maybe the word is not getting back to the factory. Perhaps Clay can pass on this kind of info...
__________________
Barry 07 EC250 |
#7
|
||||
|
||||
Dang, if only I knew someone that worked at FORD! If you could put that in plane English, I would go get one tomorrow! WTF is a degas bottle? Can you buy just the gasket, G?
__________________
Rob Granger / Katy, TX EC300 Breaking more things by 8:00AM than most people break all day. |
#8
|
|||
|
|||
I replaced my stock gas cap with a billet red one from Gasgas. It has a very large rubber seal and I expect it will last a long time.
|
#9
|
||||
|
||||
Zeal, it isn't the cap, it is the rubber gasket...
__________________
Rob Granger / Katy, TX EC300 Breaking more things by 8:00AM than most people break all day. |
#10
|
||||
|
||||
We can't get those in The Land of The Free.
|
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Base Gasket re-use? | motogroove | Enduro Engine - 2 stroke | 5 | 06-26-2011 07:56 PM |
2010 300 Cylinder Base Gasket Question | coopernicus | Enduro Engine - 2 stroke | 12 | 06-22-2011 09:31 PM |
Exhaust gasket | Biff | Enduro Engine - 2 stroke | 1 | 05-28-2011 05:48 PM |
Base gasket | Ud_luz | Enduro Engine - 2 stroke | 21 | 05-09-2008 07:38 AM |
Base Gasket | gtsnowcrack | Enduro Engine - 2 stroke | 6 | 09-09-2006 05:43 AM |