|
Enduro Engine 4 stroke (including EFI & Exhaust) 4 stroke engine, EFI, and exhaust discussion |
|
Thread Tools | Display Modes |
#1
|
||||
|
||||
Fuel pump relay-where is it?
I have new fuel pump relay for a 2005 450 FSE but I can't find the old one on the bike to replace it.
Anybody know where it's located? Could it be No 12? |
#2
|
|||
|
|||
relay
From what I have red here its behind the right hand rear side panel. Hope this works
__________________
Adam 2006 FSE450...Gone 2011 EC300e Sunshine Coast, Queensland Australia |
#3
|
||||
|
||||
It is not shown in the parts book.
|
#4
|
||||
|
||||
There are two relays there. I had to replace one once on a customers bike and the parts diagram does not show it. I replaced it with an automotive relay that was much stronger and it has worked fine since.
__________________
Claude 2019 XC300 2010 Nambotin 300 sold '07 EC300 sold '06 EC300 sold '78 Suzuki RM250C2 '75 Yamaha YZ250B sold |
#5
|
||||
|
||||
The earlier post is right, its behind the right side number plate. There are two, one for the fuel pump and one for the fan.
__________________
Dont follow me, You wont make it. |
#6
|
||||
|
||||
I guess I didn't receive a fuel pump relay.
I had been having an intermittent problem with the fuel pump not firing when I turned on the key. Now it won't start at all. I thought the fuel pump relay was bad and that it was located next to the battery under the right panel. I replaced the original with a NAPA relay but that didn't fix it. So I decided to order the factory part. When I received the part below I was hoping the the relay was still the problem but it was located somewhere else on the bike, not the relay next to the battery. I want to ride my bike again. It's dirt bike season in Texas. |
#7
|
||||
|
||||
Thats it minus the cover or shroud if you want to call it that, that surronds the spades on the relay. Will it fit with the shroud ? Also check your key switch. Unplug it and use a jumper, i've had it go fubar from water intrusion.
__________________
Dont follow me, You wont make it. |
#8
|
||||
|
||||
Unfortunately I got the wrong one.
The one in the picture is the NAPA relay, it's a direct match for the relays near the battery. In the meantime I'm going to check the key switch, that may be it. Last edited by sanderjavant; 12-20-2008 at 08:17 AM. |
#9
|
|||
|
|||
I had a intermittent starting/fuel pump problem, then total failure on my 04 quad. Turned out after much electrical trouble shooting, it was the ignition switch. One of the soldered(sp) connections was hanging on by a strand or two, then finally broke. Easy fix.
Mike.
__________________
04EC300 04Wild450 07FSR450 |
#10
|
|||
|
|||
Hope that I am way too late!
My FSE 450 acted exactly like you described although it never quite got to the point of not running at all. Installing a pair of those NAPA AR 614 relays (they are cheap, figured at worst I would have a usable spare if needed out on the trail someday) made it a different bike, no more "flame out", could hear the pump prime every time I turned on the key. So far it's my best improvement, someday I will do the master link stand fix and cut the blue/yellow wire, have to make some time for that, and to actually RIDE the bike.
Bruce
__________________
No one ever calls the Fire Department because they did something smart |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
400FSE Fuel pump question | Gi_GASGAS | Enduro Engine 4 stroke (including EFI & Exhaust) | 3 | 12-31-2019 03:58 PM |
03 450 fuel pump voltages query | hillbilly | Enduro Engine 4 stroke (including EFI & Exhaust) | 1 | 09-22-2010 04:21 PM |
fuel relay | Devondan | Enduro Engine 4 stroke (including EFI & Exhaust) | 4 | 10-21-2009 04:12 PM |
Fuel Pump Clips Broken | KTMrider58 | Enduro Engine 4 stroke (including EFI & Exhaust) | 3 | 04-15-2007 04:18 PM |