|
Enduro Engine 4 stroke (including EFI & Exhaust) 4 stroke engine, EFI, and exhaust discussion |
|
Thread Tools | Display Modes |
|
#1
|
||||
|
||||
Fuel pump relay-where is it?
I have new fuel pump relay for a 2005 450 FSE but I can't find the old one on the bike to replace it.
Anybody know where it's located? Could it be No 12? |
#2
|
|||
|
|||
relay
From what I have red here its behind the right hand rear side panel. Hope this works
__________________
Adam 2006 FSE450...Gone 2011 EC300e Sunshine Coast, Queensland Australia |
#3
|
||||
|
||||
It is not shown in the parts book.
|
#4
|
||||
|
||||
There are two relays there. I had to replace one once on a customers bike and the parts diagram does not show it. I replaced it with an automotive relay that was much stronger and it has worked fine since.
__________________
Claude 2019 XC300 2010 Nambotin 300 sold '07 EC300 sold '06 EC300 sold '78 Suzuki RM250C2 '75 Yamaha YZ250B sold |
#5
|
||||
|
||||
The earlier post is right, its behind the right side number plate. There are two, one for the fuel pump and one for the fan.
__________________
Dont follow me, You wont make it. |
#6
|
||||
|
||||
I guess I didn't receive a fuel pump relay.
I had been having an intermittent problem with the fuel pump not firing when I turned on the key. Now it won't start at all. I thought the fuel pump relay was bad and that it was located next to the battery under the right panel. I replaced the original with a NAPA relay but that didn't fix it. So I decided to order the factory part. When I received the part below I was hoping the the relay was still the problem but it was located somewhere else on the bike, not the relay next to the battery. I want to ride my bike again. It's dirt bike season in Texas. |
#7
|
||||
|
||||
Thats it minus the cover or shroud if you want to call it that, that surronds the spades on the relay. Will it fit with the shroud ? Also check your key switch. Unplug it and use a jumper, i've had it go fubar from water intrusion.
__________________
Dont follow me, You wont make it. |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
400FSE Fuel pump question | Gi_GASGAS | Enduro Engine 4 stroke (including EFI & Exhaust) | 3 | 12-31-2019 03:58 PM |
03 450 fuel pump voltages query | hillbilly | Enduro Engine 4 stroke (including EFI & Exhaust) | 1 | 09-22-2010 04:21 PM |
fuel relay | Devondan | Enduro Engine 4 stroke (including EFI & Exhaust) | 4 | 10-21-2009 04:12 PM |
Fuel Pump Clips Broken | KTMrider58 | Enduro Engine 4 stroke (including EFI & Exhaust) | 3 | 04-15-2007 04:18 PM |