|
Enduro Engine - 2 stroke Cylinder, Piston, Tranny, Bearings, Clutch, Pipes & Silencers, etc. |
|
Thread Tools | Display Modes |
|
#1
|
|||
|
|||
Pulling the right side cover without removing water pump cover?
Is this possible? I've had it off before and I'm having a major brain fart trying to remember if I need to pull the water pump cover off.
I just want to check things out in there.. have a rattly clutch that goes away when the lever is pulled in, so figured I'd check the basket out. |
#2
|
|||
|
|||
Several off the bolts holding the h2o cover on go through the side cover into the cases. Once all those bolts are out the the r side cover will come off.
|
#3
|
|||
|
|||
I never take the water pump cover off when I am taking off my right side case, I believe it's one bolt going through the cover that goes into the case that you have to loosen same as the 2 in the clutch cover.
|
#4
|
||||
|
||||
Remove the coolant drain plug and let out about half of the coolant.
Lay the bike on the floor on the shifter side. Pull the clutch cover. Do whatever work you need to do, reassemble and refill coolant. This will save oil, coolant and time. If you have the new metal shim gasket you can reuse it. |
#5
|
|||
|
|||
I ended up just pulling the small cover.. Nut is tight, basket doesn't wobble. I wonder why the clutch is so noisy until I pull the lever in? Basket looks like new. Granted, I don't really know if this just developed or not.. but I'd only noticed it in the last few months.
Last edited by GGRider01; 06-20-2016 at 01:02 AM. |
#6
|
||||
|
||||
Quote:
|
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Water pump impeller contacted cover | VxZeroKnots | Enduro Engine - 2 stroke | 1 | 01-23-2015 06:48 PM |
Water Pump Cover, Impellor, Gasket- ALL NEW! | mcnut | Parts | 0 | 12-08-2014 06:28 PM |
Water pump cover fiber gasket | r00zter | Enduro Engine - 2 stroke | 6 | 04-28-2012 03:59 PM |
Removing '05 airbox cover | Trooper Sam | Enduro Chassis & Body | 7 | 01-23-2012 11:19 AM |