|
General Discussions & Announcements General Announcements, General Questions, e.g. What bike do I buy?, etc. |
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
txt 280 2000 model wont start
Need some advice, bought a gas gas 280TXT 2 weeks ago it is a 2000 model. It was running when I bought it and it looked a nice bike for the year, Got the bike home and changed the oil as the last owner said it was probably due an oil change. I kicked it over to warm the bike up before going out on it straight after an oil change, Drove up the road going through the gears at a slow steady pace then all of a sudden the bike died. I have spent a full week looking over the bike, changing spark plug and cap also changed the coil to a fully brand new one, checked carb and all is good and plug is wet after kicking and also replaced air filter with a brand new one. I removed the fly wheel and cleaned inside the case then replaced with a brand new gasket. I have checked all earths and have cleaned with contact cleaner also disconnected the kill switch but has never started since cutting out. It?s as if it ran out of fuel but it is getting fuel still as nothing is blocked and im at a total loss with the bike.
|
#2
|
||||
|
||||
Are you sure you don't have a spark? Does the plug produce a spark if you use a new plug, connect it to the HT lead and ground and kick the engine over?
__________________
Anders "So you know, that you're over the hill when your mind makes a promise that your body can't fill" (Little Feat: Old Folks Boogie) 2015 EC200 Racing: TE bars, Rekluse Core Exp 3.0, 38mm Lectron & Ohlins S3 steering damper 2006 EC200: 2011 plastics, Rekluse Z-Start, revalved KYB forks & Scotts steering damper 1998 Bimota Supermono 1986 Duc Mille S2 1975 Guzzi sidecar hack 1961 Morini Corsaro 125 etc |
#3
|
|||
|
|||
i pressed the plug againt the head and didnt get a spark but a few friends said the same that have had or have the same bike as me but once the plug is in the head it fires straight up so i honestly have no clue ive checked every conection on the bike.
|
#4
|
||||
|
||||
Find attached some info. from the old "tech section" of what is now trialspartsusa.
Don't know if it will help, but it discusses how to test the coil and stator, among other things. I think you will really like that bike when you get it going! I have an '01 TXT 321. It is lots of fun and has great, "un-stallable" power. The 280 will be similar, I believe, and makes a very good tight single-track trail bike. Have success! Jeff TXT Electrical Information PDF.pdf
__________________
'18 GG XC 300 '05 GG DE 300 '01 GG txt 321 |
#5
|
|||
|
|||
i have changed coil and stator only thing left is the voltage regulator and cdi but cant find any online sadly
|
#6
|
||||
|
||||
A friend of mine had a similar vintage GG trials bike that would not spark. It ended up just being the the pickup at the flywheel had too big of a gap. Once the gap was closed up a bit if fired straight away.
__________________
2018 EC 300 |
#7
|
||||
|
||||
Quote:
lewisportusa.com www.splatshop.co.uk These guys know all! I'd suggest giving Jim a call at the number above. If he doesn't have it, he will likely know who does! And he'd probably be willing to talk through what you're experiencing and further diagnose. Jeff
__________________
'18 GG XC 300 '05 GG DE 300 '01 GG txt 321 |
#8
|
|||
|
|||
im from the UK sadly
|
#9
|
|||
|
|||
i have replaced the stator,CDI, coil, plug and plug cap and still no spark at all.
|
#10
|
||||
|
||||
Well, then the next thing i would do is test the integrity of of the wiring harness. It's unlikely, but not impossible, that a wire in the harness has failed, and that failure is causing lack of spark.
I had an old bmw where the wire INSIDE the insulation failed, and it would lose spark very intermittently. i had to check continuity in every wire, while moving the wiring harness. crazy. Did you also replace your timing pickup, or test it for continuity/resistance? Without that signal, your CDI won't know when to spark. I think this has been covered, but remove ALL ground leads, polish them and their mating surfaces, and reattach. I've chased bad grounds before. |
Tags |
280, gasgas, txt |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
gasgas ec300 05 model wont hit full powerband??!?!?!? | jimmyT | Enduro Engine - 2 stroke | 9 | 08-30-2011 11:31 PM |
EC200 kick start lever (2000 model) | sireid | Enduro Chassis & Body | 11 | 01-24-2010 02:56 AM |
02 EC 300 wont start | GENO 300 | Enduro Engine - 2 stroke | 0 | 09-21-2009 10:02 PM |
wont start | clerky clerk | Enduro Engine - 2 stroke | 8 | 11-01-2008 01:18 PM |
2000 Xc 250 wont start In mesa arizona | justinmanus | Enduro Engine - 2 stroke | 9 | 12-25-2006 04:46 AM |