|
Enduro Engine - 2 stroke Cylinder, Piston, Tranny, Bearings, Clutch, Pipes & Silencers, etc. |
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Weak spark
Hey guys. I?ve been using this site for years to maintain and work on my 2012 300. Took the bike around the block and it just died. Thought it was getting no spark so I tried using a ktm 300 coil new plug n wire to see if that was the problem. Kicked it once and it started, idled rough and cut off after 30 seconds. Put the old coil back on and noticed it is getting spark, just extremely weak. I?ve already cleaned my grounds, checked the stator and its spotless,no rust or corrosion. checked for shorted wires and have gotten no where. I?m at a loss. Has anyone got any insight on what this could be?
|
#2
|
||||
|
||||
Sounds like a stator issue.
Not producing enough voltage. |
#3
|
|||
|
|||
Tested the stator with multimeter it?s reading the right output
|
#4
|
||||
|
||||
I'd vote stator too. multimeter wont pick up wires that almost touch but do when they are warm. Mine failed in similar fashion.
__________________
'07 EC300 GG '14 TXT250 GG '? 496 CPI Cheetah RZ/RGV hybrid '22 765 Street Triple RS '21 XTrainer '69 Stinger T125 Suzuki '23 TRS 250RR (it's a Trials thing) |
#5
|
||||
|
||||
You need a peak voltage adapter to measure its output well enough to say if it is ok. It should be able to pump out at least 100 volts and the source coil and about 5-7 volts for the pick up. It very much sound like a weak stator. Also disconnect the kill switch to rule that out.
__________________
Back on a gassy! 2018 EC300! 🤘 Txt 280 07 to make me feel like a gumby again |
#6
|
||||
|
||||
Have you replaced the wire end and boot on the spark plug wire?
RB |
#7
|
|||
|
|||
Sometimes you can unscrew the cap, trim off a bit, then screw the cap back on so it's got a nice fresh connection.
|
#8
|
|||
|
|||
Quote:
Last edited by jmkjmk88; 08-20-2019 at 02:38 PM. |
#9
|
|||
|
|||
Anyone know where I can get a damn stator for this thing? Again it?s a 2012 ec300e headlight tail and signal lights? Not a single shop in New York will touch this thing
|
#10
|
|||
|
|||
I replied to your other post, but I'll add the answer here too.
http://www.gasgasrider.org/forum/sho...ghlight=stator
__________________
2011 EC250E |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Who said the plastic subframe is weak? | rubber Jonny | General Discussions & Announcements | 3 | 07-16-2014 07:04 AM |
Weak turnover w/ new battery | INABIL | Enduro Engine 4 stroke (including EFI & Exhaust) | 13 | 11-18-2009 10:13 PM |
weak spark | tallboy350 | Enduro Electrical & Wiring | 5 | 11-24-2008 08:18 PM |
weak spark?? | Cruiser | Enduro Engine - 2 stroke | 11 | 07-01-2007 02:26 PM |