|
Enduro Intake/Carburetion - 2 stroke Jetting, Reeds, Air Filters, etc. |
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
carb probs .bogging/ hesitation
Hi. i?m new to bikes and to 2 strokes.
I ve got hold of a 2003 EC 250 and got some problems i think are due to jetting and any advice welcome -not too technical please ! problems.. -tickover hard to set ..when hot have to adjust on handle bar throttle adj and cold runs fast ! adj for cold it wont idle hot ..just stops -heavy bogging /hesitation on 1/8 to 1/2 throttle .above 1/2 and top end good with throttle wide open. - oily goo fron silencer (normal on 2 stroke?) -if cruising plug is black and wet and eventually fouls up I cleaned the carb ,all vents clean. Cleaned exh pipe and renewed silencer padding. Clean fuel at 50.1 mix .. pwk 38 carb-i put in recommended standard jets 172 main 58 pilot. removing 185 /40.with only slight improvement..( my needle is N1 EG) Float height at 16mm W.O.T gives light brown dry plug. Compression cold is 172 psi. Reeds look good. Im at sea level to 400m. 20 to 30 Deg C ( not F!)Warm and dry climate. im not racing -just having fun. Any ideas on jetting or poss solutions- do i have a mechanical fault some where else? Thanks Gary |
#2
|
|||
|
|||
That 58 pilot is very rich. Try a 42 pilot. The main jet at 172 is in the ballpark.
|
#3
|
|||
|
|||
Thanks .will try -....also when warm and idling ,turning the mixture screw has no effect !! cheers
|
#4
|
|||
|
|||
If air mixture screw has no effect then you need to change your pilot jet. I agree with AZrickd that your pilot is hugely rich.
|
#5
|
|||
|
|||
Check my post "2012 ec 200 jetting issues". From a couple days ago. I had some very similar issues and it was related to my choke being on or partially on. The throttle cable was not adjusted properly. And to top it off my idle screw was in way too far.
Good luck. |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
300 probs????? help?? | wence | Enduro Engine - 2 stroke | 12 | 09-01-2010 10:20 PM |
07 ec 300 speedo probs !!! | pilktm | General Discussions & Announcements | 3 | 02-08-2009 12:50 PM |
Idle probs, can't seem tp resolve.. Help! | RichyN | Enduro Intake/Carburetion - 2 stroke | 18 | 12-14-2008 07:09 AM |
200 EC Electrical probs. | nwcycle | Enduro Electrical & Wiring | 6 | 10-23-2008 01:09 PM |
03 GasGas 450FSE Bogging down, TPS value? | ktownrider | Enduro Engine 4 stroke (including EFI & Exhaust) | 2 | 12-12-2007 10:34 PM |